Having problems with your Neon Computer System Cooling ?

My car is overheating. I have changed the thermistat. That was not the problem. I am thinking it's the water pump and need to know how to replace it. I do not have the owner's manule. 1998 dodge neon 2.0 L


Answers :

    \015\012
  1. \015\012Disconnect the negative battery cable.\015\012
  2. \015\012
  3. \015\012Raise and safely support the vehicle. Remove the right inner splash shield.\015\012
  4. \015\012
  5. \015\012Remove the accessory drive belts and power steering pump.\015\012
  6. \015\012
  7. \015\012Drain the cooling system into a suitable container.\015\012
  8. \015\012
  9. \015\012Securely support the engine from the bottom, then remove the right engine mount.\015\012
  10. \015\012
  11. \015\012Remove the power steering pump bracket bolts, then set the pump\015\012and bracket assembly aside, but the power steering lines do not need to\015\012be disconnected.\015\012
  12. \015\012
  13. \015\012Remove the right engine mount bracket.\015\012
  14. \015\012
  15. \015\012Remove the timing belt tensioner and timing belt\015\012
  16. \015\012
  17. \015\012Remove the camshaft sprocket(s) and inner timing belt cover
  18. \015\012
  19. \015\012Unfasten the water pump-to-engine attaching screws, then remove the water pump from the engine.
  20. \015\012
  21. Remove and discard the water pump O-ring, and thoroughly clean the mating surfaces.
To install:
\015\012
    \015\012
  1. \015\012Install a new O-ring gasket in the water pump O-ring groove. Hold\015\012the O-ring in place with a few small dabs of suitable silicone sealant.
  2. \015\012
  3. \015\012\015\012WARNING\015\012\015\012Before proceeding, make sure the O-ring gasket is properly seated\015\012in the water pump groove before tightening the screws. A improperly\015\012installed O-ring could cause a coolant leak.\015\012\015\012
    \015\012
  4. \015\012
  5. \015\012Position the water pump to the block and install the retainers.\015\012Tighten the retainers to 9 ft. lbs. (12 Nm). Use a pressure tester to\015\012pressurize the cooling system to 15 psi and check the water pump shaft\015\012seal and O-ring for leaks.\015\012
  6. \015\012
  7. \015\012Rotate the pump by hand to check for freedom of movement.\015\012
  8. \015\012
  9. \015\012Install the inner timing belt cover, timing belt and tensioner.\015\012
  10. \015\012
  11. \015\012Install the right engine mount bracket and engine mount.\015\012
  12. \015\012
  13. \015\012Refill the cooling system with the proper type and amount of coolant.\015\012
  14. \015\012
  15. \015\012Install the power steering pump and accessory drive belts.\015\012
  16. \015\012
  17. \015\012Connect the negative battery cable.\015\012
  18. \015\012
  19. \015\012Use a DRB or equivalent scan tool to perform the camshaft and crankshaft timing relearn procedure, as follows:\015\012\015\012
      \015\012
    1. \015\012Connect the scan tool to the Data Link Connector (located under the instrument panel, near the steering column).\015\012
    2. \015\012
    3. \015\012\015\012 Turn the ignition switch\015\012 ON\015\012 , and access the miscellaneous screen.\015\012 \015\012
    4. \015\012
    5. \015\012Select the re-learn cam/crank option, then follow the instructions on the scan tool screen.\015\012
Thanks for using FixYa - a Very Helpful rating is appreciated for answering your FREE question.
Repair Help & Product Troubleshooting for Neon Computer System Cooling

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

My car is overheating. I have changed the thermistat. That was not the problem. I am thinking it's the water pump and need to know how to replace it. I do not have the owner's manule. 1998 dodge neon 2.0 L


\015\012\015\012Disconnect the negative battery cable.\015\012 \015\012\015\012Raise and safely support the vehicle. Remove the right inner splash shield.\015\012 \015\012 ... Neon Computer System Cooling

Tightening HP Pavilion DV9000 17'' LCD Hinges


You may find the hinges parts from eBay which is cheaper price:\015\012http://shop.ebay.ca ... HP Pavilion dv6000z Notebook

Windows wont start. dont know how it happened.


Press F2 to go to the system setup, then press arrow down to highlight Standard CMOS feature, then press enter. Verify if the hard drive is detected, mostly it is installed in SATA 0 and you should see like a serial no of the Hard drive. If the hard ... Dell Inspiron 530 Desktop Computer (ddcwda1_7) IntelPentium dual-core processor E2140 (1MB L2,1.60GH

HP Pavilion dv 9205 us tries to start up, screen stays black


THIS IS A LONG REPLY POST BE WARNED : HOWEVER IS LIKELY HELPFUL TO OTHERS WITH INTERMITTENT LCD / PORT ISSUES. MY STORY,... Hi all. Ok, i'm gonna chime in here on this. I have the HP DV9205us and i've returned my unit a total of three times. Ultimate ... HP Pavilion dv9205us Notebook

Cant find where the cmos battery goes in my toshiba satellite a45 s151 laptop


On a Toshiba Satellite A45-S151, the CMOS battery (also called the\015\012“real time clock” or RTC battery) is located under the wrist rest to\015\012the right of the trackpad. This means that you’ve got some major\015\012surgery ah ... Toshiba Satellite A45-S151 Notebook

PCGK33 Fan Issue


Attention Sony PCG K series noisy fans owners.\015\012Do not try to modify/replace your fans, they are running fine.\015\012The noise is caused by the tightly packed dust on the radiator wall of the processor.\015\012Solution: ... Sony PCGK37 Notebook

Monitor does not turn on


Normal 0 false false false MicrosoftInternetExplorer4 \015\012 /* Style Definitions */ table.MsoNormalTable\011{mso-style-name:"Table Normal";\011mso-tstyle-rowband-size:0;\011mso-tstyle-colband-size:0;\011mso-style-nosh ... Dell E173FP 17" LCD Monitor

Cant do anything, I turn it on, get windows screen, next says windows restarting


With the hard drive removed power up the system and enter the CMOS setup utility. Make sure that it is working properly. If not then get an external monitor and plug it into the VGA port on your laptop. (should be D-shaped with 15 holes for pins). In ... Toshiba Satellite 5105-S701 (PS511U-02WYJX) PC Notebook

Chang mainboard - HP Compaq dx2300 Microtower - RT950UTABA PC Desktop


Normal 0 MicrosoftInternetExplorer4 \015\012 /* Style Definitions */ table.MsoNormalTable\011{mso-style-name:"Table Normal";\011mso-tstyle-rowband-size:0;\011mso-tstyle-colband-size:0;\011mso-style-noshow:yes;\011mso-style-parent:"" ... HP Compaq dx2300 Microtower - RT950UTABA PC Desktop

Blue screen on start-up saying 'stop: c000007b bad image' etc


The odds are, you will need to replace the HDD. Best odds for data recovery are to get a new drive and a universal HDD adapter (here is an example: ... Dell Inspiron E1705 Notebook

Can't set up network w linksys modem


Video card:Your computer has an integrated video card but has a "PCI Express" expansion slot for an upgrade. After the upgrade you will be able to play most games without the choppy frame rate...depending on what card you buy. Since ... PC Desktops

Wont boot up to bios


I have had TWO recent model NEC laptops with the same symptom in the past 5 months. I was quite surprised, since NEC is a quality product. But the problem was the DVD/CD-Rom, which is made by Philips (mine were Philips SCB5265 models, but there are o ... NEC Versa SX Notebook

Dell laptop Battery issue (does not charge)


All i can suggest is cleaning the conectors between the battery and the laptop, unfortuantley if that doesnt work then your battery has died im afraid and a replacement is all you can do, im on my laptop now and the same thing has happened with this ... Dell Inspiron 1525 Notebook

3.3 seems ok


Carl,\015\012\015\012does the hard drive spin up? if not it may indicate the fan is on the 5V rail and not the 12V rail.\015\012\015\012P013 definately doesn't appear correct and i would guess is the problem component.\0 ... Acer Aspire L100 PC Desktop

Volume control is constantly on


It may be a malfunctioning circuit board controlling the buttons on the front. If it's under warranty ship it back to Philips; if not markgladding on this site sent me the following advice. Standard disclaimers apply and any questions or comments sho ... Philips 190B6CB/27 19" LCD

Operating System Not Found, Can't Use CD Drive


I'm afraid you have a hard disk problem, it has probably failed.If you have entered your BIOS and the hard disk has been set to auto (detect) and when you boot up and you press F1 to continue and get a message "Operating System not found" then ... PC Laptops

Install more memory, install new dvd/cd drives


As far as the memory in your system goes, each memory slot can hold DDR2 PC2-8500, DDR2 PC2-5300, or DDR2 PC2-6400 with a maximum of 1GB per slot. You can add two 1GB modules to your present configuration if you choose.\015\012\015\012For ... Gateway 835GM (835GH) PC Desktop

Averatec 6200 rw dvd drive doesnt work


YEs, typically that sound means the Hard Drive crashed. Although you may be able to still use it, its not recomended. Hopefully you backed up you important files because most likely they are un-recoverable. Does the laptop boot at all? If so, do you ... Averatec 6200 Notebook

I need to know how to replace the fan assembly on TM 2480


I can't seem to find any posts online from other owners of the TM 2480 who have tried taking apart their laptop. Disassembling a laptop is a bit of an intuitive business and you have to take it slowly and carefully if you're not that familiar with ta ... Acer PC Laptops

I have a Samsung Syncmaster 932b LCD monitor. When I turn it on, the screen just flashes on and off, as does the blue light around the power button. I read up online and found that the capacitors on the power supply were bad, so I opened the monitor and found the power supply motherboard and I found 3 of the capacitors were bulging. I am looking to replace them, but I can't seem to find out exactly what kind of capacitors they are. The capacitors themselves have the following written on them,


Savato321, Most black screen lcd monitor owners don't have the smarts to open up their monitors to do a VISUAL inspection of the "switch-mode-power-supply/inverter supply!!!! You're good. Now you will need to know some stuff about electrolytic filter ... Samsung SyncMaster 932B LCD Monitor

Intel D845GLAD motherboard


This is indeed listed as a Memory error by Intel\015\012\015\0123 beeps = Base 64K memory failure\015\012\015\012the name of that probably doesn't say much to the average PC user, but for those of us who remember the good ole ... PC Desktops

Keyboard failure and diskette drive 0 seek failure


Been trying to figure this out for weeks have you tried a Dell keyboard It has worked for others but not for me and no It won't boot from CD because u need the keyboard to press any key to activate boot I even tried a flash drive to boot but my boot ... Dell Dimension C521 PC Desktop

Starts to the Fujitsu Screen then nothing


No Actually its fixable \015\012\015\012There are a number of issues that can cause this but all of them are hardware related.. Mostly its eighter the hard drive or them main board (bios)\015\012\015\0121.) Open up the laptop ... Fujitsu LifeBook N3520 Notebook

I have a laptop motherboard (da0at3mb8f0) which will not power on. I see a small charred area on the motherboard right on the power input circuit. I want to replace these diodes/resistors but I cant tell the value of them since their toasted. How can I find service manuals or schematics to know what I need to replace?


I have the same motherboard,which ones you want to know the value? r4=10k, r6=0, r5 and r7 whitout component (empty),d1 it's marked whit 0Ch, it's a simple diode.i hope this could be useful (and excuse my english, i don't use it often) ... PC Laptops

IBM T30 laptop- replacing CMOS battery


Provided the laptop booted (albeit to requiring bios set up), all is well. The data such as time needs to be re-entered manually, because since the battery is required to maintain volatile memory, when the battery goes flat or is removed, the data is ... IBM ThinkPad T30 2366 Notebook
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.electronic-servicing.com || Terms of Use || Contact || Privacy Policy
Load time: 0.9622 seconds